Specification Sheet: VP 315/022-RC

- 1.2 GHz Intel^® Pentium^® M Processor based Dual PMC Embedded Controller

RUGGEDIZED DUAL PMC CONTROLLER

• conduction cooled to IEEE 1101.2

• conformally coated

• air cooled version available:-

  • see VP 315/022-RA datasheet

•  non-ruggedized version available:-

  • see VP 315/02x datasheet

CENTRAL PROCESSOR

• Intel^® Pentium^® M Processor:-

  • uses µFC-BGA 479 (micro Flip-Chip Ball Grid Array) package

  • operating at 1.2GHz

  • 64 Kbytes of primary (Level 1) on-die cache

  • 1 Mbyte of secondary (Level 2) on-die cache

  • 400 MHz Front Side Bus (FSB)

• utilizes 64-bit Intel^® 855GME chipset:-

  • supports 400 MHz bus frequency

• utilizes Intel® 6300ESB I/O Controller Hub

DRAM

• supporting 1 Gbyte of 266 MHz DDR ECC SDRAM soldered on the board

• single bit error correction

• accessible from processor or VME bus

EIDE HARD DISK INTERFACES

• supports up to Ultra-DMA 100 for high
  performance drives

• primary channel is accessible via P2 connector

SERIAL ATA INTERFACE

• Serial ATA (SATA) interface:-

  • one SATA port via P0

• supports up to 150 Mbytes/s transfer rates

ETHERNET INTERFACE

• implemented by Intel^® 82546GB LAN Controller via
  64-bit/66 MHz PCI bus

• two interfaces supporting 10Base-T,
  100Base-TX, 1000Base-T:-

  • one or both interfaces accessed via P0

• support for VITA 31.1:-

  • Gigabit Ethernet for VME64x backplanes

GRAPHICS INTERFACE

• implemented by the Intel^® 855GME GMCH host bridge providing:-

  • resolutions up to 2048 x 1536 @75Hz

  • up to 16M colors

• analog graphics interface supported via P0

PMC (PCI MEZZANINE CARD) INTERFACE

• 2 x PMC sites and for both sites:-

  • I/O via P2 for site 1 and via P0 for site 2

  • 32/64-bit and 33/66 MHz PCI operation

  • 3.3V PCI signaling

• expansion to optional dual PMC carrier board:-

  • using one baseboard PMC site

  • 64-bit/66 MHz

SERIAL INTERFACE

• 2 x serial channel interfaces

• 16550 compatible UART

•  rear panel access:-

  • 2 x RS232/422/485, both via P2

SOFTWARE SUPPORT

• support for VxWorks^®, Linux^®, Windows^® NT, Windows^® 2000, Windows^® XP, Windows^® XP Embedded, RTX^®, QNX^®, Solaris^®, LynxOS^® and MS-DOS^®

FLASH EPROM

• 64 Mbytes Application Flash EPROM

• 512 Kbytes of BIOS Flash EPROM

• user specified CMOS settings held in BIOS Flash EPROM

FIRMWARE SUPPORT

• Phoenix^® BIOS

• comprehensive Power-On Self-Test (POST)

• LAN boot firmware included

OTHER PERIPHERAL INTERFACES

• PC-compatible Real Time Clock (Year 2000 compliant):-

  • default time loaded from BIOS Flash EPROM

• 2 x USB 2.0 interfaces, one via P2 connector and one via P0 connector

• keyboard and mouse interfaces accessed via P0 connector

• watchdog timer

• 1 x 32-bit Long Duration Timer with processor interrupt capability

VME INTERFACE

• implemented using Tundra^® Universe II™ device

• VME Master/Slave

• A32/A24/A16/D64/D32/D16/D8(EO)/MBLT64

• fast hardware byte swapping

• auto system controller detect

• full interrupter / interrupt handler support

• bus error interrupt hardware

ELECTRICAL SPECIFICATION

• +5V@3.4A (typical with 1 Gbyte DRAM)

• +12V@0A; -12V@0A

• +12V and -12V routed to both PMC sites

ENVIRONMENTAL SPECIFICATION

• operating temperatures:-

  • -40°C to +85°C (no airflow)

• 10% to 95% Relative Humidity, non condensing (operating)

• -45°C to +100°C (storage)

• 10% to 95% Relative Humidity, non condensing (storage)

• altitude (operating): -1,000 to 50,000 feet (-305 to 15,240 metres)

• non-ruggedized wide temperature versions available:-

  • see VP 315/02x datasheet

SAFETY

• PCB (PWB) manufactured with flammability rating of 94V-0

MECHANICAL SPECIFICATION

• 6U form-factor

• single VME slot - front panel width 0.8inch (20.3mm)

• utilizes 160-way DIN connectors for P1 and P2

• utilizes P0 2mm connector

• shock:

  • 40g, 11ms, ½ sine (operating)

• sine vibration:

  • 5Hz-2000Hz at 5g, peak (operating)

•  random vibration:

  • 0.1 g²/Hz (10Hz-1KHz); -6dB/octave (1KHz-2KHz) (operating)

• rear plug compatible with commercial non-ruggedized
  VP 315/02x:-

  • see separate VP 315/02x datasheet

• rear plug compatible with ruggedized air cooled
  VP 315/022-RA:-

  • see separate VP 315/022-RA datasheet